Ceramics vs Alnico for Guitar Pickups
When I read that ceramic magnets sound harsh and alnico magnets sound sweet, I ask myself, ” Who the hell preaches such nonsense?” There are harsh-sounding pickups with alnico magnets and sweet-sounding pickups with ceramic magnets and vice-versa! A magnet by itself has no sound, and as a part of a pickup, the magnet is simply the source to provide the magnetic field for the strings. The important factor is the design of a magnetic circuit which establishes what magnet to use.
Though ceramic magnets cost less than alnico magnets of equal size, a well-designed magnetic circuit using ceramic magnets costs much more than the six Alnico 5 magnets of a traditional single coil pickup!
Before the introduction of alnico magnets in 1935, permanent magnets were not quite that permanent. During a certain time, they lost a good amount of magnetism till they finally reached a stable condition. The process to accelerate this decay was called in the industry, “magnetic aging.” In modern science, it is called “stabilizing.” Since the 50’s, we use Alnico 5 magnets which lose, under normal conditions, less then half a percent per 100 years.
How do we achieve normal conditions?
Alnico magnets are shipped by the manufacturer in a non-magnetized condition and will not be magnetized until a pickup is completed.
How to maintain normal conditions?
After magnetization, avoid any close contact with other pickups or magnets facing either north to north or south to south with their magnetic poles. Don’t ever throw pickups random in a drawer; you may either use a keeper on each side of the magnetic poles or carefully place them with the north facing the south pole of the other magnet. guitar pickup magnets ( For tele players, remember that the iron backplate of a traditional tele pickup functions as a keeper which increases the stability of the magnets.)
Once pickups are in a guitar, there is very little to worry about. That your pickups lose some of their magnetism when you lean your guitar against an amp is nothing but a fairy tale. Or, that pickups lose some of their magnetism when you drop them on a concrete floor is just another fairy tale — alnicos and ferrites will break before they have any measurable losses. Magnets are sensitive to heat, but so is your guitar. However, heat can be a severe problem when an Alnico 5 magnet is exposed to temperatures above 1000 F, approaching its Curie temperature of 1634 F. At these temperatures, alnico rod magnets for guitar Alnico 5 undergoes structural changes and cannot be re-magnetized. Why do I mention this? Because it happens quite often, when someone doesn’t like the unbalance in output of a pickup with staggered magnets and goes to a bench grinder or a belt sander to grind a magnet down. You take a chance that a magnet gets too hot and becomes damaged.
Guitar Pickup Separate Magnets Alnico Rods, Alnico 2,3,5,8 Polepieces Vintage Staggered Set Rod Magnets for Pickup Bobbin, Alnico Separate Cylindrical Magnets, Pickup Separate Round Bar Magnets * Magnet Merial: Alnico 2,3,4,5,8 / Alnico I, II, III, IV, V, VIII/ A2, A3, A4, A5, A8 * Top Characteristic: Flat, Vintage Bevel, Modern Bevel (Chamfer) * Stagger Option: Stagger I / Stagger II / Stagger III * Diameter: […]
ALNICO 8 Rod Pickup Separate Magnets Vintage Stagger Set, Rough / Sand Cast Alnico A8 Flush Pole Mounted Polepiece Magnets, Guitar Pickup Bobbin Alnico VIII Polepiece Rods Vintage Staggered Set * Magnet Merial: Alnico 8 / Alnico VIII / A8 / Al 8 * Top Characteristic: Vintage Flat * Stagger Option: Stagger I / Stagger II / Stagger III * Diameter: 0.187 […]
Rough / Sand Cast Alnico 2 Flush Pole Mounted Polepiece Magnets for Guitar Pickup Bobbin, Guitar Pickup Bobbin Rough Alnico II Polepiece Rods Vintage Staggered Set, Alnico 2 Pickup Rod Separate Magnets Based on the Vintage Stagger * Magnet Merial: Alnico 2 / Alnico II / A2 * Top Characteristic: Flat, Vintage Bevel, Modern Bevel (Chamfered) * Stagger Option: Stagger I / Stagger […]
Guitar Pickup Bobbin Alnico 3 Polepieces Vintage Staggered Set, Sand Cast Alnico 3 Flush Pole Mounted Polepiece Magnets for Guitar Pickup Bobbin, Alnico 3 Pickup Rod Magnets Based on the Vintage Stagger, Cast Alnico Cylinder Guitar Pickup Magnets * Magnet Merial: Alnico 3 / Alnico III / A3 * Top Characteristic: Flat, Vintage Bevel, Modern Bevel (Chamfer) * Stagger Option: Stagger […]
Alnico 5 Polepieces Vintage Staggered Set Rod Magnets for Pickup Bobbin, Alnico 5 (A5) Polepiece Guitar Rod Cylindrical Magnets, Vintage Staggered Set Alnico V Permanent Magnet in Neck Pickup Bobbin, Bridge Pickup Bobbin Cast Alnico 5 guitar rod magnets similar to the ones found in vintage pickups from the ’50s. includes 6 pieces as specified below. * Magnet Merial: Alnico 5 / Alnico […]
Vintage Beveled Pickups Alnico 5 Cylindrical Magnet (0.250″Diameter), Chamfered Alnico 5 Polepiece Rod Magnet FOR Telecaster or Stratocaster Type Guitar Pickup Assembly, 0.250″Diameter Vintage Beveled Guitar & Bass Pickups Alnico 5 Cylinder Magnet HS-GPAR-5 with vintage beveled top / chamfered Fueature: * Permanent Magnet Merial: AlNiCo 5 / Alnico V / A5 * Diameter: 0.250 in * Length: 0.471 in 0.630 in 0.650 in 0.665 in. 0.671 in 0.688 in […]
Cast Modern Bevel Alnico 5 Polepiece Guitar Rod Magnets Chamfered, Alnico V Rod Guitar Magnets, Cast AlNiCo 5 Guitar Pickup Rod Magnets Modern Beveled Top, Polished / Unpolished Vintage Staggered Bass Pickups Alnico 5 Cylindrical Bar Magnet HS-GPAR-5 with modern beveled top / chamfered Fueature: * Permanent Magnet Merial: AlNiCo 5 / Alnico V / A5 * Diameter: 0.187 in / 0.195 in * […]
ALNICO 5 Rod Cylinder Magnets Vintage Bevel, Alnico V Guitar Magnets, Guitar Pickup Magnets (Imperial) – Polished, ALNICO 5 Rod Bluk Magnets Vintage Stagger Set ( 0.187″, 0.195″, 0.250″) HS-GPAR-5 with vintage beveled top Fueature: * Permanent Magnet Merial: AlNiCo 5 / Alnico V / A5 * Diameter: 0.187 in / 0.195 in / 0.250 in * Length: 0.471 in 0.630 in […]